Richard Allan Scientific Msds Sheets
fermiwords

Richard Allan Scientific Msds Sheets

Skin Contact: Remove contaminated clothing and shoes immediately.Wash effected area with soap or mild detergent and large amounts of water.If irritation persists, seek medical Ingestion: if swallowed, induce vomiting by giving two glasses of water and sticking fingers down throat.

Keep victim's head lower than hips to prevent aspiration into lungs.Never give anything by mouth to an unconscious person.Call a physician immediately.

ANTIDOTE: Give ethanol, 50% (100 proof), 1.5 mL/Kg orally initially, diluted to no more than 5% solution, followed by 0.5-1.0 mL/Kg every 2 hours orally or intravenously for 4 days in order to reduce metabolism of methanol and to allow time for its excretion.

Blood ethanol level should be in the range of 1-1.5 mg/mL (Dreisbach, Handbook of Poisoning, 12th ed.).Antidote should be administered by qualified medical personnel.Buffer Solutions:Wash affected area with copious amounts of water for at least 15 minutes.If ingested, contact a physician.FIRE FIGHTING PROCEDURESFIRE AND EXPLOSION HAZARD: DANGEROUS FIRE HAZARD AND MODERATE EAT, FLAME, OR OXIDIZERS.VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL A CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.

VAPOR-AIR MIXTURE IS EXPLOSIVE.

LOWER EXPLOSIVE LIMITS: 6.0%

UPPER EXPLOSIVE LIMIT: 36.0%

AUTOIGNITION TEMP: 752F (385C)

FIRE FIGHTING MEDIA: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR ALCOHOL-RESISTANT FOAM (1993 Emergency Response Guidebook, DOT P 5800.5).FOR LARGER FIRES USE WATER SPRAY, F(1993 Emergency Response Guidebook), DOT P 5800.5).

UNUSUAL FIRE AND EXPLOSION HAZARDS: Containers may explode in fire, methanol burns with a non-luminous blue flame.Vapors are heavy and will travel long distances back to a source of ignition.

POISONOUS GASES ARE PRODUCED IN THE FIRE.

CONTAINERS MAY EXPLODE IN FIRE.

VENTILATION:Provide local exhaust or process enclosure ventilation to meet the published exposure limits.Ventilation equipment must be explosion-proof.RESPIRATORY PROTECTIONWhere the potential exists for exposures over 200 ppm, use a NIOSH approved respirator with an organic vapor cartridge/canister.More protection is provided by a full facepiece respirator than by a half-mask respirator, and even greater protection is provided by a powered-air purifying respirator.

FOR FIRE FIGHTING AND OTHER IMMEDIATELY DANGEROUS TO LIFE OR HEALTH CONDITIONS: Any self-contained breathing apparatus that has a full face piece and is operated in a pressure-demand or other positive-pressure mode.Any supplied-air respirator that has a full face piece and is operated in a pressure-demand or other positive-pressure mode in combination with an auxiliary self-contained breathing apparatus operated in pressure-demand or other positive-pressure mode.

CLOTHING:Employee must wear appropriate protective (impervious) clothing and equipment to prevent repeated or prolonged skin contact with this substance.

Employee must wear appropriate protective gloves to prevent contact with this substance.ACGIH recommends NITRILE rubber or VITON as good to excellent protective materials.

Employee must wear splash-proof or dust-resistant goggles to prevent eye contact with this substance.

EMERGENCY EYE WASH:Where there is any possibility that an employee's eyes may be exposed to this substance, the employer should provide an eye wash fountain within the immediate work area for emergency use
richard allan scientific msds sheets
.Eye wash stations must, at a minimum, provide a full 15 minutes EXPOSURE LIMITS:100% Methyl Alcohol (Methanol):

200 ppm (260 mg/m3) OSHA TWA (SKIN); 250 ppm (310 mg/m3) OSHA 200 ppm (262 mg/m3) ACGIH TWA (SKIN); 250 ppm (328 mg/m3) 200 ppm (260 mg/m3) NIOSH RECOMMENDED TWA (SKIN);

250 ppm (325 mg/m3) NIOSH RECOMMENDED STEL

200 ppm (260 mg/m3) DFG MAK TWA (SKIN);

400 ppm (524 mg/m3) DFG MAK 30 MINUTE PEAK, AVERAGE VALUE, CHROMATOGRAPHY WITH FLAME IONIZATION DETECTION; (NIOSH VOL.III #2000, METHANOL).

CYANURIC CHLORIDE:Violent reactionDICHLOROMETHANE:Possible ignition and explosionDIETHYL ZINC:Possible ignition and explosionHYDROGEN PEROXIDE + WATER:Explosion hazardIODINE + ETHANOL + MERCURIC OXIDE:Explosion hazardCorrodesExplosion hazardViolent reactionMixtures are capable of detonationPossible ignition in the presence of nickel catalyst.NITRIC ACID (CONCENTRATED):Mixture of greater than 25% acid may decompose violentlyFire and explosion hazardPERCHLORIC ACID:Explosion hazardPHOSPHOROUS TRIOXIDE:Possible violent reaction and ignitionPossible dangerous reactionPOTASSIUM HYDROXIDE + CHLOROFORM:Exothermic reactionFire and explosion hazardSODIUM + CHLOROFORM:Possible explosionSODIUM HYPOCHLORITE:Explosion hazardSODIUM METHOXIDE + CHLOROFORM:Violent reactionSULFURIC ACID:Fire and explosion hazardExplosion hazardDECOMPOSITION: Thermal decomposition products may include toxic oxides of carbon.

Hazardous polymerization has not been reported to occur under normal temperatures and pressures.Buffer Solutions: Stable under normal temperatures and pressures

Avoid contact with the following: Oxidizing agents, reducing agents, amines, mercaptants.

DECOMPOSITION: Thermal decomposition may yield the following: Hydrogen chloride, sulfur dioxide, oxides of nitrogen.

Product will not undergo polymerization

SARA TITLE III (Superfund Amendment and Reauthorization Act) SECTION 302 AND 304: Extremely hazardous substance list (40 CFR 355) - Not listed

SECTION 311: Hazardous Categorization (40 CFR 370) - Acute, Chronic and Fire

SECTION 313: Toxic Chemicals Listed (40 CFR 372.65) - Listed as a toxic chemical

CERCLA (Comprehensive Environmental Response, Compensation, and Liability Act)SECTION 102 (A): Hazardous Substance (40 CFR 302.4) - Listed

REPORTABLE QUANTITIES: 5,000 lbs.

SECTION 101(4): Reportable Quantities: 5,000 lbs.

RCRA (Resource Conservation and Recovery Act)40 CFR 261.21 Hazardous Waste Number: U154/D001

NJ (New Jersey - State Right to Know)Environmental Hazardous Substance List: Listed, Substance #1222

TSCA (Toxic Substance Control Act)Methanol is listed on TSCA Inventory.llan Scientific, is intended for legal use in laboratories and manufacturing environments.Sysmex America, Inc.

provides the information contained herein in good faith, but makes no representative claim or warranty as to its completeness or accuracy.

This document is intended only as a guide for appropriate handling of the material described by properly trained persons using the product according to its intended purposes.

Individuals receiving this information retain the responsibility for determining the suitability of the information for any specific purposes.

Users should consider these data only as supplement to other information gathered by themselves, and must make independent determinations of the suitability and completeness of information from all sources to ensure proper use and disposal of these materials, and for the safety and health of employees and customers.

No warranty, expressed or implied, is made with regard to such information.Permission is granted to make unlimited copies of this MSDS for internal purposes only.

Revised September 2007.
© 2012 labroda
Downloadic - infolari - Contact · Privacy Policy